Rattle during low speeds and light throttle
#42
Senior Member
#43
#44
I cant find where a rattle is coming from and wondering if any other Ford Owners have found this
2015 XLT 3.5EB. Crew 5.5 box
49,000 miles
When driving between 20-35 mph I will let off the gas (all is good) then slight accelerate in which it does not down shift (Causing a slight bog down) there is a rattle. If I let off the gas it goes away. If I accelerate more it will go away.
That I can tell, it will only only do this during those lower sleeps.
A friend thought may be a heat shield but it could not find anything rubbing or loose.
Any Help?
2015 XLT 3.5EB. Crew 5.5 box
49,000 miles
When driving between 20-35 mph I will let off the gas (all is good) then slight accelerate in which it does not down shift (Causing a slight bog down) there is a rattle. If I let off the gas it goes away. If I accelerate more it will go away.
That I can tell, it will only only do this during those lower sleeps.
A friend thought may be a heat shield but it could not find anything rubbing or loose.
Any Help?
#45
My truck does the same. What I tracked it down to is the PCV valve. They tend to rattle quite a bit when the engine is cold thanks to the spring that is inside them. Best thing to do is remove the engine cover and then start the truck when cold to confirm that the PCV valve is the cause. If it is, it is harmless and just annoying.
The following users liked this post:
johnday in BFE (10-27-2021)
#46
Fidel. Thanks for posting the picture. I have a 2015 Lariat SCREW. I was getting the rattle around 1000 rpm's. Was driving me nuts. When I checked this clamp, it was actually broken and just dangling on the exhaust pipe. I just grabbed it and took it off.
#47
2016 3.5 Ecoboost. Was the heatshield by wastegate. Just bent it with some pliers for now but may have to cut it as others suggested. This was driving me bat sh*t crazy. Only happened in gear and at low RPMs.
#48
Senior Member
Sub'd. I just picked my truck up after 33 days at the dealership getting the cam phasers replaced. I asked them to diagnose the same rattling noise on decel/coasting/low RPM but they were unable to duplicate my concern....
I've checked the heatshield before but thought it was fine. I'll double check that as well as the one by the wastegate and hope that cures the problem. It's super annoying.
I've checked the heatshield before but thought it was fine. I'll double check that as well as the one by the wastegate and hope that cures the problem. It's super annoying.
The following users liked this post:
Iphylgood (08-19-2023)
#49
2015 F-150 3.5L eco
Check post #24.....I had the same issue and it was the heat shield right on top of the section of the muffler running from the drivers side. check for a clamp ; it should be tighten around the shield on the drivers side, it is welded on the passenger side. In my case, the clamp was corroded and broken (see the new clamp in the photo). Don't get deceived by the tightness of the shield, believe me, if the clamp is not holding the shield, it will rattle! Please, rotate the photo..... This is a 2016 XLT 350 ecoboost