I have a 2005 ford f150 with the 4.6 litre. I drive it every day. The other day otw home from work, It just died. Like I had run out of gas. 3/4 tank of gas. The fuel pump wasn't working. I replaced the module at the spare tire.. nothing.. I replaced the fuel pump... still nothing. I don't see a relay for the fuel pump, but I hear one clicking when I turn the key on. Stumped..
Any suggestions??

 

Did you check if your fuel pump safety switch was tripped? Its located by the fuse box in the passenger side kick panel.

 

Check fuse #34 in the passenger side kick panel. If the fpdm was cracked open, water can get into it causing a short thus blowing fuse #34.

 

This. A lot of the time this fuse goes pretty quick once the FPDM shorts.

 

Found the problem. Under the driver side door, where the wires plug together for the fuel line, there were two brojen wires. Soldered in a jump wire and truck cranked right up.